INDEX OF DTC
P0100 Air Mass Flow (HFM) Malfunction ..................... 7
P0102 Low HFM Sensor Signal (Circuit Open) ........... 7
P0103 High HFM Sensor Signal (Circuit Short) .......... 8
P0105 Supply Voltage Fault to Booster Pressure
Sensor ............................................................... 8
P0106 High Booster Pressure Sensor Signal ............ 9
P0107 Booster Pressure Sensor Open/GND Short.... 9
P0108 Booster Pressure Sensor Short..................... 10
P0109 Low Booster Pressure Sensor Signal ........... 10
P0110 Intake Air Temperature Circuit
Malfunction - Source Power Problem............. 11
P0112 Intake Air Temperature Circuit
Malfunction - Open .......................................... 12
P0113 Intake Air Temperature Circuit
Malfunction - Short .......................................... 13
P0115 Supply Voltage Fault to Coolant Temperature
Sensor ............................................................. 13
P0117 Coolant Temperature Sensor Malfunction
- Open .............................................................. 13
P0118 Coolant Temperature Sensor Malfunction
- Short .............................................................. 14
P0120 Accelerator Pedal Sensor #1 Malfunction
- supply Voltage Fault...................................... 14
P0122 Accelerator Pedal Sensor #1 Malfunction
- Open .............................................................. 14
P0123 Accelerator Pedal Sensor #1 Malfunction
- Short .............................................................. 14
P0147 Impossible to Learn Idle MDP ........................ 15
P0148 Impossible to Learn Drive MDP ..................... 15
P0171 Insufficient MDP of Injector #1 ........................ 15
P0172 Insufficient MDP of Injector #2 ........................ 15
P0173 Insufficient MDP of Injector #3 ........................ 15
P0174 Insufficient MDP of Injector #4 ........................ 15
P0175 Insufficient MDP of Injector #5 ........................ 15
P0180 Fuel Temperature Sensor - Malfunction......... 15
P0182 Fuel Temperature Sensor - Short to Ground . 16
P0183 Fuel Temperature Sensor - Short to B+ ......... 16
P0190 Supply Voltage Fault to Fuel Rail
Pressure Sensor............................................. 17
P0191 Fuel Rail Pressure Sensor Signal Fault ........ 17
P0192 Fuel Rail Pressure Sensor Malfunction
- Open .............................................................. 17
P0193 Fuel Rail Pressure Sensor Malfunction
- Short .............................................................. 18
P0201 Injector #1 Circuit Open .................................. 18
P0202 Injector #2 Circuit Open .................................. 18
P0203 Injector #3 Circuit Open .................................. 18
P0204 Injector #4 Circuit Open .................................. 18
P0205 Injector #5 Circuit Open .................................. 18
P0215 Main Relay Fault - Stuck.................................. 19
P0219 Too Small Clearance of Crank Angle Sensor 19
P0220 Accelerator Pedal Sensor #2 Malfunction
- Supply Voltage Fault...................................... 19
P0222 Accelerator Pedal Sensor #2 Malfunction
- Open .............................................................. 19
P0223 Accelerator Pedal Sensor #2 Malfunction
- Short .............................................................. 19
P0243 VGT Turbocharger Actuator Circuit Short ....... 20
P0245 Turbo Charger Actuator Circuit Fault - Short .. 20
P0246 Turbo Charger Actuator Circuit Fault
- Short to B+ ..................................................... 20
P0251 IMV Driver Circuit Malfunction - Short ............. 20
P0253 IMV Driver Circuit Malfunction - Short to
Ground ............................................................. 20
P0255 IMV Driver Circuit Malfunction - Open ............. 20
P0263 Injector #1 Balancing Fault ............................. 21
P0266 Injector #2 Balancing Fault ............................. 21
P0269 Injector #3 Balancing Fault ............................. 21
P0272 Injector #4 Balancing Fault ............................. 21
P0275 Injector #5 Balancing Fault ............................. 21
P0325 Accelerometer #1 (Knock Sensor)
Malfunction ...................................................... 21
P0325 Accelerometer #1 (Knock Sensor)
Malfunction ...................................................... 22
P0335 No Crank Signals ............................................ 22
P0336 Too Large Clearance of Crank Angle Sensor 22
P0341 Cam Position Sensor Malfunction
(Poor Synchronization).................................... 22
P0344 Cam Position Sensor Malfunction ................. 22
P0372 Crank Angle Sensor Malfunction .................... 23
P0400 EGR Control Valve Fault.................................. 23
P0401 EGR Control Valve Fault (Low) ....................... 23
P0402 EGR valve stuck in open position................... 23
P0405 High EGR open position deviation................. 24
P0406 High EGR close position deviation ................ 24
P0407 Low EGR Position Signal ............................... 24
P0408 High EGR Position Signal .............................. 25
P0480 PWM Electric Fan Malfunction (Open circuit)
(Only for D27DTP (POWER UP) model) ......... 25
P0481 PWM Electric Fan Malfunction(Short to B+)
(Only for D27DTP (POWER UP) model) ......... 25
P0482 PWM Electric Fan Malfunction (Short to GND)
(Only for D27DTP (POWER UP) model) ......... 25
P0483 Fan PWM motor out have short to GND ......... 25
P0484 Fan PWM Stall motor ...................................... 25
P0485 Fan PWM motor have over load...................... 25
P0487 Faulty Maximum Throttle Closing Value ......... 25
P0488 Faulty Maximum Throttle Opening Value ........ 26
P0530 Air Conditioner Refrigerant Sensor Supply
Power Fault ..................................................... 26
P0532 Air Conditioner Refrigerant Pressure Signal
Circuit Short..................................................... 26
P0533 Excessive Air Conditioner Refrigerant
Pressure.......................................................... 27
P0560 Battery Voltage Malfunction ............................. 27
P0562 Low Battery Voltage ......................................... 27
P0563 High Battery Voltage ........................................ 28
P0571 Brake Pedal Switch Fault ................................ 28
P0602 Faulty Vehicle Speed Sensor Coding.............. 28
P0606 ECU Watchdog Fault ...................................... 28
P0608 Faulty ABS/ESP Coding ................................... 29
P0611 No Data for C3I................................................ 29
P0612 Internal Error in C3I Data ................................ 29
New DTC
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
5
DIAGNOSIS
ECU
B R A K E E C U T C U A / B A G T C RK-STICS F F H R/SENSOR F A T C TGS-LEVER P / T R U N K C C C S
New DTC
P0613 Faulty TCU Coding .......................................... 29
P0614 TCCU Coding Failt.......................................... 29
P0618 Multi Calibration Not Performed ..................... 29
P0619 Multi Calibration Performing Error.................. 29
P062D Injector Bank #1 Malfunction - Low Voltage ... 29
(former P1611)
P062E Injector Bank #2 Malfunction - Low Voltage ... 29
(former P1618)
P062F Multi Calibration Memory Error ....................... 30
P0630 Variant Coding is not done ............................. 30
P0631 Variant Coding writing error ............................ 30
P0633 Immobilizer Fault
(refer to immobilizer section).......................... 30
P0641 ECU Supply Voltage 1 Fault (5 V) ................... 30
P0642 ECU Supply Voltage 1 Fault - Low (5 V) ......... 30
P0643 ECU Supply Voltage 1 Fault - High (5 V) ........ 30
P0649 Diag Lamp Drive Open Circuit ....................... 30
P0650 Diag Lamp Drive Short to BATT ...................... 30
P0651 ECU Supply Voltage 2 Fault (5 V) ................... 31
P0652 ECU Supply Voltage 2 Fault - Low (5 V) ......... 31
P0653 ECU Supply Voltage 2 Fault - High (5 V) ........ 31
P066A Internal Malfunction in #1 Glow Plug
Controller......................................................... 31
P066B Internal Short in #1 Glow Plug Controller ...... 31
P066C Internal Malfunction in #2 Glow Plug
Controller......................................................... 31
P066D Internal Short in #2 Glow Plug Controller ...... 31
P066E Internal Malfunction in #3 Glow Plug
Controller......................................................... 31
P066F Internal Short in #3 Glow Plug Controller ...... 31
P0670 Defective Power Supply of Glow Plug
Controller......................................................... 31
P0671 #3 Glow Plug Fault - Open.............................. 32
P0672 #4 Glow Plug Fault - Open.............................. 32
P0673 #5 Glow Plug Fault - Open.............................. 32
P0674 #1 Glow Plug Fault - Open.............................. 32
P0675 #2 Glow Plug Fault - Open.............................. 32
P067A Internal Malfunction in #4 Glow Plug
Controller......................................................... 32
P067B Internal Short in #4 Glow Plug Controller ...... 32
P067C Internal Malfunction in #5 Glow Plug
Controller......................................................... 32
P067D Internal Short in #5 Glow Plug Controller ...... 32
P0683 Defective CAN Communiction of Glow Plug
Controller......................................................... 32
P0685 Main Relay Malfunction ................................... 33
P0697 ECU Supply Voltage Fault (2.5 V) ................... 33
P0698 ECU Supply Voltage Fault - Low (2.5 V) ......... 33
P0699 ECU Supply Voltage Fault - High (2.5 V) ........ 33
P0700 TCU Signal Fault ............................................. 33
P0704 Clutch Switch Malfunction ............................... 33
P0805 Neutral Signal Input Malfunction
(Only for D27DT M/T model) ............................ 33
P1102 HFM Sensor - High Characteristic Value
(Only for D27DT model)................................... 34
P1103 HFM Sensor - Low Characteristic Value
(Only for D27DT model)................................... 34
P1105 Barometric Sensor Circuit Short .................... 34
P1106 Booster Pressure Sensor Malfunction ........... 34
P1107 Barometric Sensor Circuit Short/GND Short.. 34
P1108 Barometric Sensor Circuit Short .................... 34
P1109 Booster Pressure Sensor Initial Check Fault 35
P110A AMF OBD High Sigral...................................... 35
P110B AMF OBD Low Sigral....................................... 35
P1115 Coolant Temperature Sensor Malfunction ..... 35
P1120 Accelerator Pedal Sensor #1 Malfunction...... 36
P1121 Accelerator Pedal Sensor #2 Malfunction...... 36
P1122 Accelerator Pedal Sensor Malfunction
(Limp Home Mode) ......................................... 36
P1123 Accelerator Pedal Sensor Malfunction
(Torque Mode) ................................................. 36
P1124 Accelerator Pedal Sensor Malfunction - Stuck 36
P1148 Accelerometer (Knock Sensor) Learning
Fault ................................................................. 36
P1149 Too High Water Level in Fuel Filter................. 36
P1170 Torque Trim Fault - High ................................. 36
P1171 #1 Injector MDP Malfunction ........................... 36
P1172 #2 Injector MDP Malfunction ........................... 36
P1173 #3 Injector MDP Malfunction ........................... 37
P1174 #4 Injector MDP Malfunction ........................... 37
P1175 #5 Injector MDP Malfunction ........................... 37
P1190 Fuel Rail Pressure Sensor Initial Signal
Fault ................................................................. 37
P1191 Pressure Build Up - Too Slow ........................ 37
P1192 Fuel Rail Pressure Sensor Initial Signal
Fault - Low ....................................................... 38
P1193 Fuel Rail Pressure Sensor Initial Signal
Fault - High ...................................................... 38
P1201 Injector #1 Circuit Short................................... 38
P1202 Injector #2 Circuit Short................................... 38
P1203 Injector #3 Circuit Short................................... 39
P1204 Injector #4 Circuit Short................................... 39
P1205 Injector #5 Circuit Short................................... 39
P1234 VGT Operation Fault (High)............................. 39
P1235 VGT Operation Fault........................................ 39
P1252 Too High IMV Pressure ................................... 39
P1253 Minimum Rail Pressure Control Malfunction
(IMV Fault) ........................................................ 40
P1254 Maximum Rail Pressure Control Malfunction
(IMV Fault) ........................................................ 40
P1256 Too Small Transfer Pressure Fuel in Rail
Pressure System ............................................ 41
P1257 Too Large Transfer Pressure Fuel in Rail
Pressure System ............................................ 41
P1258 Too Small High Pressure Fuel in Rail
Pressure System ............................................ 42
P1259 Too Large High Pressure Fuel in Rail
Pressure System ............................................ 42
P1260 Too High IMV Driving Current.......................... 43
P1286 Low Resistance for Injector #1 Wiring
Harness........................................................... 43
P1287 High Resistance for Injector #1 Wiring
Harness........................................................... 43
P1288 Low Resistance for Injector #2 Wiring
Harness........................................................... 44
P1289 High Resistance for Injector #2 Wiring
Harness........................................................... 44
P1290 Low Resistance for Injector #3 Wiring
Harness........................................................... 44
CHANGED BY
EFFECTIVE DATE
AFFECTED VIN
6
DIAGNOSIS
ECU
New DTC
P1291 High Resistance for Injector #3 Wiring
Harness........................................................... 45
P1292 Low Resistance for Injector #4 Wiring
Harness........................................................... 45
P1293 High Resistance for Injector #4 Wiring
Harness........................................................... 45
P1294 Low Resistance for Injector #5 Wiring
Harness........................................................... 46
P1295 High Resistance for Injector #5 Wiring
Harness........................................................... 46
P1405 EGR Solenoid Valve Malfunction - Short to
Ground ............................................................. 46
P1406 EGR Solenoid Valve Malfunction
- Short to +Batt ................................................. 46
P1407 Faulty EGR close position .............................. 47
P1409 EGR Valve Circuit Short................................... 47
P1480 Condenser Fan #1 Circuit Malfunction - Open.. 47
P1481 Condenser Fan #1 Circuit Malfunction - Short .. 47
P1482 Condenser Fan #1 Circuit Malfunction
- Short to Ground............................................. 47
P1500 Vehicle Speed Fault ........................................ 48
P1501 Faulty Variant Coding (Vehicle Speed) ........... 48
P1503 Faulty Vehicle Speed Sensor Input................. 48
P1526 Condenser Fan #2 Circuit Malfunction - Open 48
P1527 Condenser Fan #2 Circuit Malfunction - Short 48
P1528 Condenser Fan #2 Circuit Malfunction - Short to
Ground ............................................................. 49
P1530 #1 Heater Operating Circuit - Open................ 49
P1531 #1 Heater Operating Circuit - Short ................ 49
P1532 #1 Heater operating circuit - Short to Ground 49
P1534 #2 Heater Operating Circuit - Open................ 49
P1535 #2 Heater operating circuit - Short ................. 50
P1536 #2 Heater operating circuit - Short to Ground 50
P1540 Air Conditioner Operating Circuit Fault - Open50
P1541 Air Conditioner Operating Circuit Fault - Short50
P1542 Air Conditioner Operating Circuit Fault -
Short to Ground ............................................... 50
P1564 Auto Cruise Switch Fault (power) ................... 50
P1565 Auto Cruise Switch Malfunction (Acceleration)50
P1566 Auto Cruise Switch Malfunction (OFF)............ 50
P1567 Auto Cruise Switch Malfunction (Return) ....... 50
P1568 Auto Cruise Switch Fault (when accelerating) 50
P1568 Auto Cruise Switch Malfunction (Deceleration) 50
P1569 Auto Cruise Switch Fault (when decelerating)50
P1569 Auto Cruise Switch Malfunction (Safety) ........ 50
P1570 Auto Cruise Switch Fault (Signal)................... 51
P1571 Brake Lamp Signal Fault ................................ 51
P1572 Brake Lamp Signal Fault ................................ 51
P1573 Auto Cruise Switch Fault (Short) .................... 52
P1578 Auto Cruise Switch Fault (Circuit Short)......... 52
P1600 ECU Shut Down Fault ..................................... 52
P1601 ECU Fault ........................................................ 52
P1602 ECU Fault ........................................................ 52
P1603 ECU Fault ........................................................ 52
P1604 ECU Fault ........................................................ 52
P1605 ECU Fault ........................................................ 53
P1606 ECU Fault ........................................................ 53
P1607 ECU Injector Cut Fault .................................... 53
P1608 ECU Fault ........................................................ 53
P1614 ECU C2I/MDP Fault......................................... 53
P1615 ECU Fault ........................................................ 53
P1616 ECU Fault ........................................................ 53
P1620 ECU Fault ........................................................ 53
P1621 ECU Fault ........................................................ 53
P1622 ECU Fault ........................................................ 53
P162E Injector Bank #1 Malfunction - High Voltage .. 54
(former P1619)
P162D Injector Bank #2 Malfunction - High Voltage .. 54
(former P1612)
P1630 Wrong response from Immobilizer (refer to
immobilizer section) ....................................... 54
P1631 Immobilizer Fault (refer to immobilizer section)55
P1632 Immobilizer Fault (refer to immobilizer section)55
P1633 Immobilizer Fault (refer to immobilizer section)55
P1634 Immobilizer Fault (refer to immobilizer section)55
P1635 No response from Immobilizer (refer to
immobilizer section) ....................................... 55
P1636 Immobilizer Fault (refer to immobilizer section) . 56
P1650 AMF OBD Short to GND................................... 56
P1657 Engine Mount Control Malfunction (Open)..... 56
P1658 Engine Mount Control Malfunction (Short to B+) 56
P1659 Engine Mount Control Malfunction
(Short to GND) ................................................. 56
P1671 #3 Glow Plug Fault - Short .............................. 56
P1672 #4 Glow Plug Fault - Short .............................. 56
P1673 #5 Glow Plug Fault - Short .............................. 56
P1674 #1 Glow Plug Fault - Short .............................. 57
P1675 #2 Glow Plug Fault - Short .............................. 57
P1676 Glow Plug Communication Fault ................... 57
P1677 Glow Plug Controller Fault.............................. 57
P1678 Glow Plug Malfunction - Open ........................ 57
P1679 Glow Plug Malfunction - Short ........................ 58
P1680 Glow Plug Malfunction - Short to Ground ....... 58
P1683 Defective CAN Communiction of Glow Plug
Controller......................................................... 58
P2100 Throttle Drive Circuit Short.............................. 58
P2101 Throttle Drive Ground Short ............................ 58
P2102 Throttle Drive Short ......................................... 58
P2103 Throttle Drive Battery Short ............................. 59
P2104 Throttle Drive Overheat ................................... 59
P213B Abnormal Throttle Control............................... 59
P213C Low Throttle Signal ......................................... 60
P213D High Throttle Signal ........................................ 60
P2671 #3 Glow Plug Short (Battery) .......................... 61
P2672 #4 Glow Plug Short (Battery) .......................... 61
P2673 #5 Glow Plug Short (Battery) .......................... 62
P2674 #1 Glow Plug Short (Battery) .......................... 62
P2675 #2 Glow Plug Short (Battery) .......................... 63
P3040 ECU Internal Malfunction ................................ 63
P3041 ECU Internal Malfunction ................................ 63